Pressure-Canned Lima Beans (Fresh, Large)

Ingredients

Instructions

1. 1Lima beans are a low-acid food, so this recipe must be processed in a pressure canner; a boiling-water bath canner cannot reach the temperature needed to destroy Clostridium botulinum spores and is not safe for canning lima beans.
2. 2Wash canning jars in hot, soapy water or run them through a dishwasher, then keep the jars hot in simmering water, a warm oven, or the dishwasher until ready to fill; simmer new two-piece lids in hot (not boiling) water according to the manufacturer's instructions until ready to use.
3. 3Shell about 7 pounds of fresh large lima bean pods to yield roughly 3 pounds of shelled beans, then rinse the beans well.
4. 4Use the hot-pack method for best quality: cover the shelled lima beans with boiling water in a pot, bring to a boil, and boil for 3 minutes (raw pack is also approved, though hot pack gives better quality).
5. 5Fill jars loosely with the hot lima beans — leave room since the beans expand and need liquid circulation — then cover with the boiling cooking liquid; add 1/2 teaspoon canning salt per pint or 1 teaspoon per quart if desired for flavor only, as it is not needed for safety.
6. 6Fill jars only about two-thirds to three-quarters full of beans, top off with boiling liquid, and leave 1 inch of headspace.
7. 7Slide a non-metallic spatula or bubble remover between the food and the jar in two or three places to release trapped air bubbles, adding more liquid if needed to restore the correct headspace; wipe the jar rim clean with a damp paper towel, center a prepared lid on the jar, and screw on the metal band until fingertip tight.
8. 8Place the filled jars on the rack in the pressure canner, add the amount of water called for in your canner's manufacturer instructions (typically 2 to 3 inches), lock the canner lid in place, and heat on high; let steam vent steadily and forcefully from the open petcock or vent for a full 10 minutes to purge all air from the canner before closing the petcock or setting the weighted gauge on the vent pipe.
9. 9Because these are large lima beans, process pint jars for 50 minutes and quart jars for 60 minutes (small lima beans need slightly less time, but always use the longer large-bean time if bean size is mixed or uncertain): in a weighted-gauge canner use 10 pounds of pressure at altitudes up to 1,000 feet or 15 pounds above 1,000 feet; in a dial-gauge canner use 11 pounds up to 2,000 feet, 12 pounds at 2,001-4,000 feet, 13 pounds at 4,001-6,000 feet, or 14 pounds at 6,001-8,000 feet.
10. 10When the processing time is finished, turn off the heat and let the canner depressurize naturally — never run water over it, jiggle the weight, or open a petcock to force cooling — this takes about 30 to 45 minutes; wait until a dial gauge reads zero, or on a weighted-gauge canner wait at least 2 minutes after the last hiss of escaping steam, then remove the weight or open the petcock and wait 10 more minutes before unlocking and carefully removing the lid, tilting it away from your face to let the last of the steam escape.
11. 11Using a jar lifter, remove the jars and set them upright, spaced at least an inch apart, on a towel or cooling rack in a draft-free spot, and let them cool undisturbed for 12 to 24 hours.
12. 12Once the jars are completely cool, check each seal by pressing the center of the lid — it should be firm and not flex or pop; remove the screw bands, wipe down the jars, and label each one with its contents and the date it was canned.
13. 13Store sealed jars in a cool, dark place and use within about 1 year for best quality; because this is a low-acid vegetable, always boil the contents hard for 10 minutes (adding 1 additional minute for each 1,000 feet above sea level) before tasting or serving, and discard without tasting any jar with an off odor, spurting liquid upon opening, or a lid that is unsealed, bulging, or leaking.